Renault Trafic model includes a series of cargo vans and utility vans. The first car was produced back in 1981 and is still being produced. Also known as Nissan Primastar, Opel Vivaro. We present information about the second generation Renault Traffic relays and fuse boxes released in 2001, 2002, 2003, 2004, 2005, 2006, 2007, 2008, 2009, 2010, 2011, 2012, 2013 and 2014.
The number of boxes and their versions may differ from this material and depend on the country of delivery, year of manufacture and equipment.
Locations
Diagram
Designation
| 1 | ABS electronic control unit – underfloor |
| 2 | Air conditioning / heater control unit |
| 3 | Accumulator battery |
| 4 | Diagnostic connector (DLC) |
| 5 | Electronic engine control module (ECM) |
| 6 | Fuse / relay box, engine compartment |
| 7 | Fuse / relay box, instrument cluster 1 |
| 8 | Fuse / relay box, instrument panel 2 |
| 9 | Fuse / relay box, under the floor |
| 10 | Glow plug relay |
| 11 | Heater blower motor resistor – in the heater block |
| 12 | Sound signal |
| 13 | Inertial fuel cut-off switch |
| 14 | Multifunctional control unit -functions: Anti-theft system, central locking, alarm, rear window defogger, immobilizer, direction indicators, interior lamps, windshield wiper / washer |
| 15 | Navigation system control unit |
| 16 | Ambient air temperature sensor – in the mirror of the right door |
| 17 | Parking system control unit |
| 18 | SRS electronic control unit |
| 19 | Electronic Transmission Control Module (TCM) – Transmission ASM |
| 20 | Vehicle speed sensor – on the gearbox (some models) |
Passenger compartment
The main fuse box is located at the rear of the instrument panel.
On the reverse side of the protective cover, the current diagram with the arrangement of the elements will be glued.
Diagram
Assignment
| 1 | 15A Audio system, light relay, alarm, display, navigation ECU, tachograph |
| 2 | 10A Interior lighting |
| 3 | 15A Fog lamp relay |
| 4 | 15A Signal, Switches: outdoor lighting, direction indicators, fog lights |
| 5 | 25A Signal, Switches: outdoor lighting, direction indicators, fog lights |
| 6 | 30A Screen wipers and washers |
| 7 | 10A ECU, manual transmission, ECU, starter relay and fuel pump |
| 8 | 25A Interior heater |
| 9 | 10A Central locking, Diagnostic connector, Instrument panel, steering angle sensor |
| 10 | 30A Central locking |
| 11 | 15A Direction indicator |
| 12 | 30A Relay for heated rear window and exterior mirrors |
| 13 | 25A Signal, Switches: outdoor lighting, direction indicators and fog lights |
| 14 | 25A Relay for electric water pump of the auxiliary heating system, Auxiliary air distribution block |
| 15 | 15A Rear running lights – switch, Fuel heating relay, reverse light, windshield wiper |
| 16 | 10A Central locking, Heated rear window, Glove box lighting, Instrument panel, climate control, headlight range control |
| 17 | 10A Vehicle speed sensor, Steering angle sensor, ABS ECU, ESP ECU |
| 18 | 15A Heater control panel, Wipers and washers, Audio system, relay dimensions, dipped headlights, rear window wiper, display |
| 19 | 10A Brake Light Switch, Diagnostic Connector, AirBag ECU and Parking Aid, Rain and Light Sensor, ESP Switch |
| 20 | 15A Interior heater, auxiliary heater relay, Heated driver and passenger seats – switches |
| 21 | 30A Electric windows |
| 22 | 30A Rear window wiper: engine and relay |
| 23 | 10A High beam headlights |
| 24 | 25A Passenger Climate Control Panel, Auxiliary Heating System – Water Pump Relay |
| 25 | 5A Relay for unloading the supply circuit “+” of the battery with a time delay for the interior light |
| 26 | 10A Heated exterior mirrors |
| 27 | 15A Cigarette lighter – 1st row of seats, Additional equipment – 1st row of seats |
| 28 | 25A Heater and air conditioner fan, Climate control – control panel |
| 29 | 10A Display, Daytime Running Light – Main Relay, Audio System, Navigation ECU |
| 30 | 15A Additional 12 V socket – 1st row of seats |
| 31 | 15A Additional 12 V socket – 2nd row of seats |
| 32 | 15A Sound signal |
| 33 | 10A Fog lights |
| 34 | 10A Side lights – starboard |
| 35 | 10A Side lights – port side, Instrument lighting |
| 36 | 10A Low beam – right headlight |
| 37 | 10A Low beam – left headlight |
| 38 | 10A High beam – right headlight |
| 39 | 10A High beam left headlight |
The fuse number 27, 15A, is responsible for the cigarette lighter.
The presence of additional boxes with relays in the instrument panel is possible.
- Heated rear window relay
- Rear window wiper / washer relay
- Rear wiper relay
- Relay for main ignition circuits
- Windshield heater relay
- Fog lamp relay
Engine compartment
Type 1
In the engine compartment, the fuse box is located on the left side under a protective cover.
The photo
Diagram
Assignment
| Power supply circuit protection unit (777) | |
| 1A | Reserve |
| 1B | 70A Passenger compartment fuse box, preheating unit |
| 1C | 60A Immersion heater 1 & 4 relay |
| 1D | 60A Immersion heater 2 & 3 relay |
| 1E | Reserve |
| 1F | 60A Cooling fan – relay |
| Engine circuit protection unit (1834) | |
| 1 | 25A ECU |
| 2 | 15A Engine power supply circuit |
| 3 | 10A A / C Compressor Electromagnetic Clutch |
| 4 | 20A Fuel heater relay |
| Power supply circuit protection unit (1841) | |
| 2A | 60A Passenger compartment fuse box, Consumer relay 1 |
| 2B | Reserve |
| 2C | 60A Relays 1 and 2 “+” after ignition feed, Relay for auxiliary heater of passenger compartment |
| 2D | 60A Passenger compartment fuse box, Burglar alarm |
| 2E | Reserve |
| 2F | 40A Electric fan for heater and air conditioner |
Type 2
Diagram
Protected components
| 1 | Auxiliary heater: 2 or 3 add-on heater |
| Diesel: Parking heater relay | |
| 2 | Diesel: Relay for fuel injection computer |
| Petrol: Injection interrupt | |
| 3 | Diesel pump relay |
| 4 | Fuel pump/diesel pre-heating relay |
| 5 | Diesel parking heater: Relay for fan unit, second speed level |
| 6 | Coupling relay: AC compressor |
| 7 | 1 add-on heater (thermo-plunger) relay |
| 8 | 2 or 3 add-on heater (thermo-plungers) |
| Petrol: Parking heater relay | |
| 9 | Diesel: Fan unit |
| Diesel: Relay for second speed level with AC | |
| Petrol: First speed level with AC | |
| 10 | Petrol: Fan unit |
| Diesel: Relay for first speed level of the fan with AC | |
| Petrol: Second speed level with AC | |
| 11 | Not used |
| 12 | Relay for heatable windscreen. |
| 13 | Relay for heatable windscreen. |
| 14 | Not used |
| 15 | Not used |
| 16 | 40A AC |
| 17 | 50A Windscreen heating |
| 18 | 50A Windscreen heating |
| 19 | 60A PDB |
| 20 | 60A ABS |
| 21 | 60A PDB |
| 22 | 60A PDB |
| 23 | 50/60/70A Radiator fan |
| 24 | 50/60A Warning autofuse |
| 25 | 70A Pre-heating |
That’s all. If you want to add something – write in the comments.
Hi, Any help on this very much appreciated.
I have a Renault Trafic Phase 2 Passenger 2009 (Type 1 above I believe)
Rear Fog light is stopped working. Checked Bulb, wiring, fuse etc… Maybe the switch I guess but have wasted a lot of time looking for the relay. I believe it has one as it mentions fog relay on fuse 3. Can you advise please?
Many thanks, Tim
Help please. My battery went flat because I left a light on. When jumping it my friend put the leads the wrong way round. Now ignition is dead. No lights at all when I put key in and turn it. Please advise what’s wrong. Thank you
The cab fan is on without key in the ignition
Disconnect battery terminal
Reconnect
Fan still on
Which relay needs removing to stop the fan
Until I can get it to a garage
Kind regards
I have a nissan perimeter 2011 battry wanted charging now fully charged new battery i have no ignition no lights on dash nothing at all when turning ignition any suggestions thanks Bill
I have 2007 Renault Traffic which my auto electrician says there is no signal to the fuel pump (diesel) and I am trying to establish where the fuel relay is as I have checked all fuses car will wind over but wont start
Hi, I have a Vauxhall Viraro 2009, the key fob has stopped working, a person I know plugged in the diagnostic computer and it just says inactive, tried resetting the key but still doesn’t work, any advice please?
Hi, I have a 2007 Renault traffic van, horn isn’t working, replaced 15amp fuse and behind wheel airbag with no luck. I’m reading about a relay/ fuse under battery under floor but not finding it? Thanks