The 2nd generation Ford Expedition was produced in 2003, 2004, 2005, 2006 and was designated as U222. In this article you will find a description of the fuses and relays Ford Expedition 2 with a box diagram and a photo of an example of execution. Note the cigarette lighter fuse.
The purpose of the fuses and relays may differ from that shown and depends on the year of manufacture and the level of equipment.
Is it the wrong generation or the diagrams are not suitable? See other Ford Expedition:
[ Ford Expedition 1G (1996-2002) ]
[ Ford Expedition 3G (2007-2014) ]
[ Ford Expedition 4G (2018-2024) ]
Passenger compartment
The fuse and relay box is located under the right-hand side of the instrument panel.
To remove the fuse box cover, place a finger behind the PULL tab and your thumb above the PULL tab as shown in the illustration, then pull the cover off.
Or
Photo
Diagram
Assignment
| 1 | 7.5 | Run/Accessory – Front wiper motor, Instrument cluster, Rear wiper motor |
| 2 | 20 | Turn signal/Hazard flasher, Stoplamp switch, Stoplamps, Center high-mount stop light (CHMSL), Turn signal lamps |
| 3 | 7.5 | Power mirror switch, Power mirrors (non-memory), Driver seat switch (memory), Memory module (logic power) |
| 4 | 15 | DVD player, Rear seat audio controls, CDDJ (navigation radio) |
| 5 | 7.5 | Powertrain Control Module (PCM) (KA power), Speed control deactivation switch, Manual climate control mode switch, Stoplamp switch, Brake-shift interlock (BSI) solenoid, EATC control head, Body Security Module (BSM) (KA power), 3rd row seat relay coils, SecuriLock LED |
| 6 | 15 | Headlamp switch (parklamps and switch backlight feed), Parklamps, License plate lamps, Foglamp relay coil, Trailer tow electric brake controller (illumination), BSM (autolamp, parklamps) Foglamp indicator |
| 7 | 5 | Radio (start signal) |
| 8 | 10 | Rear window defroster switch, Rear window defroster indicator (climate control head), Heated outside mirrors |
| 9 | – | Not used |
| 10 | 20 | Trailer tow back-up lamps relay, Trailer tow 7–wire connector (back-up lamps), Trailer tow parklamp relay, Trailer tow 7– and 4–pin connectors (parklamps) |
| 11 | 10 | A/C compressor clutch relay, A/C compressor clutch solenoid, 4×4 Integrated Wheel Ends (IWE) solenoid |
| 12 | 15 | Fuel pump relay, Fuel pump shut-off switch, Fuel pump driver module, Fuel pump motor |
| 13 | 10 | Manual climate control mode switch, Rear window defroster relay coil, A/C refrigerant containment switch, A/C de-icing switch, A/C low pressure switch, DATC control head, DATC solenoids, DATC blower control, Trailer tow battery charge relay coil |
| 14 | 10 | Daytime Running Lamps (DRL) ignition relay coil, Digital Transmission Range Sensor (DTRS) back-up lamps, Trailer tow back-up lamps relay coil, Electrochromatic mirror, Manual A/C blend door actuator |
| 15 | 5 | AdvanceTrac® with RSC switch, Instrument cluster (Run/Start feed) |
| 16 | 10 | BS/AdvanceTrac® with RSC module (Run/Start feed) |
| 17 | 15 | Foglamps |
| 18 | 10 | Auxiliary A/C temperature blend door actuator, Auxiliary A/C front auxiliary control, Turn signal flasher, Electrochromatic mirror, Auxiliary mode motor |
| 19 | 10 | Restraints Control Module (RCM) |
| 20 | 30 | BSM (door locks, liftgate glass release relay), Liftgate glass release motor, Door/Liftgate lock motors |
| 21 | 15 | Instrument cluster (B+), Interior (courtesy) lamps, Puddle lamps (outside mirrors) |
| 22 | 10 | Moonroof switch illumination, Radio (delayed accessory feed), Flip window switch, Flip window motors, EHAM antenna amplifier (navigation radio) |
| 23 | 10 | RH low beam |
| 24 | 15 | Interior demand lamps (front map/dome lamp, 2nd row dome/map lamp, glove compartment lamp, cargo lamp, roof rail lamps, vanity mirror lamps), Battery saver relay coil, Battery saver relay power, Heated Positive Crankcase Ventilation (PCV) valve |
| 25 | 10 | LH low beam |
| 26 | 20 | Horn relay, Horns |
| 27 | 5 | Compass module, Reverse sensing system module, Brake shift interlock solenoid, Overdrive cancel switch, Air suspension module (Run/Start sense) |
| 28 | 5 | PCM relay coil, SecuriLock transceiver, Heated PCV valve relay coil |
| 29 | 30 | Trailer tow electric brake controller, Trailer tow 7–wire connector (electric brake) |
| 30 | 25 | Air suspension module (air spring solenoids and height sensors), PCM (4×4 transfer case clutch) |
| 31 | 20 | Radio (B+), Subwoofer |
| 32 | 15 | Catalyst Monitor Sensors (CMS), Transmission solenoids, Canister vent solenoid, HEGO sensors, VMV solenoid, A/C compressor clutch relay coil, CMCV, VCT actuators |
| 33 | – | Not used |
| 34 | 15 | PCM, Fuel injectors, Mass Air Flow (MAF) sensor |
| 35 | 20 | Instrument cluster high beam indicator, High beam headlamps |
| 36 | 10 | Trailer tow right turn/stop lamps |
| 37 | 20 | Cargo area power point |
| 38 | 25 | Rear wiper motor, Washer pump (rear window wash) |
| 39 | 20 | Console power points (front and rear of console), Instrument panel power point (bench seat) |
| 40 | 20 | DRL relays, DRL foglamps, DRL headlamp relay coil, Headlamp switch (headlamps), Multifunction switch (flash-to-pass), BSM (autolamp headlamps relay), High beam relay coil, Fuse 25 (LH low beam), Fuse 23 (RH low beam) |
| 41 | 20 | Cigarette lighter, OBD II diagnostic connector |
| 42 | 10 | Trailer tow left turn/stop lamps |
| 101 | 30 | Starter motor relay, Starter motor solenoid |
| 102 | 30 | Ignition switch power |
| 103 | 30 | ABS/AdvanceTrac® with RSC module (pump motor) |
| 104 | 30 | LH 3rd row seat relay, LH 3rd row seat switch, LH 3rd row seat motor |
| 105 | 30 | Spare |
| 106 | 30 | Trailer tow battery charge relay, Trailer tow 7–way connector (battery charge) |
| 107 | 30 | Auxiliary A/C blower relay, Auxiliary A/C blower motor |
| 108 | 30 | Passenger seat motor switch |
| 109 | 30 | Driver seat motor switch (non-memory), Memory module, Power memory mirrors, Adjustable pedals switch and motor |
| 110 | 30 | Spare |
| 111 | 50 | Air suspension compressor, Air suspension compressor relay |
| 112 | 30 | ABS/AdvanceTrac® with RSC module (valves) |
| 113 | 30 | Front wiper motor, Washer pump (windshield wash) |
| 114 | 40 | Rear window defroster relay, Rear window defroster grid, Heated mirrors (Fuse 8) |
| 115 | 30 | Transfer case shift motor, 4×4 relays |
| 116 | 40 | Front blower motor relay, Front blower motor |
| 117 | 30 | RH 3rd row seat relay, RH 3rd row seat switch, RH 3rd row seat motor |
| 118 | 30 | Driver and passenger climate control seat module |
| 401 | 30 | Power windows (circuit breaker), Main window switch, Window motors, Window switches, Moonroof module |
| R01 | Starter relay: Starter motor solenoid | |
| R02 | Delayed accessory relay: Fuse 22, CB 401, Power windows, Switch backlighting, Radio, Moonroof, Flip windows, Navigation antenna amplifier | |
| R03 | Hi-beam relay: Fuse # 35, Hi-beam headlamps, Hi-beam indicator | |
| R04 | Rear window defrost relay: Fuse 8 (heated mirrors), Rear window defroster, Heated outside mirrors, Rear window defroster indicator (climate control head) | |
| R05 | Trailer tow battery charge relay: Trailer tow 7–wire connector (battery charge) | |
| R06 | Front blower relay: Front blower motor | |
| R201 | Trailer tow park lamp relay: Trailer tow 7–wire and 4–wire connectors (park lamps) | |
| R202 | Foglamp relay: Front foglamps | |
| R203 | PCM relay: Fuse 32, Fuse 34, PCM solenoids and sensors | |
| R301 | Trailer tow back-up lamp relay: Trailer tow 7–wire connector (back-up lamps) | |
| R302 | Heated PCV valve relay: Heated PCV valve | |
| R303 | Fuel pump relay: Fuel pump shut-off switch, PCM (fuel pump monitor), Fuel pump, Fuel pump driver module | |
| R304 | Battery saver relay: Roof rail lamps, Vanity mirror lamps, Map/Dome lamp, Glove box lamp, Cargo area lamp, Outside mirror puddle lamps, Instrument cluster (interior lamps) | |
| R305 | Horn relay: Dual note horn |
Cigar lighter (power outlet) fuses in the Ford Expedition 2G are the fuses №37 (Cargo area power point), №39 (Instrument panel or floor console power point, Rear console power point) and №41 (Cigar lighter) in the Passenger compartment fuse box.
Under the hood, there may also be some boxes with fuses and relays responsible for operation: cooling fan relays, seat folding relays, DRL relays, etc.
We also published a video on this post. Check it out and don’t forget to subscribe to the channel!
If you have something to add – write in the comments.