Chevrolet Malibu 7st generation was produced in 2008, 2009, 2010, 2011, 2012. In our post you will find a detailed description of the Chevrolet Malibu 7G fuse and relay boxes with diagrams and photographs. Let’s highlight the fuse responsible for the cigarette lighter.
The description of the fuses may differ from the one shown and depend on the year of manufacture and the equipment level of your car.
Location
Passenger compartment
You’ll find the fuse box for the instrument panel on the passenger side panel of the centre console. To access the fuses, just open the fuse panel door from the passenger side by pulling it out.
Diagram
Assignment
| 1 | 15A Body Control Module (Door Locks) |
| 2 | 10A Body Control Module (Interior Lamps) |
| 3 | 2A Steering Wheel Controls |
| 4 | 10A 2008: Adjustable Pedals Module, Adjustable Pedals Position Switch |
| 5 | 10A Vehicle Communication Interface Module (VCIM (OnStar)) |
| 6 | 2A Outside Rearview Mirror Switch |
| 7 | 10A Heated Seat Control Module (Driver/Passenger), Heated Seat Switch (Driver/Passenger), Inside Rearview Mirror, Sunroof Control Module |
| 8 | – |
| 9 | – |
| 10 | 10A Windshield Wiper/Washer Switch |
| 11 | – |
| 12 | 2A Power Steering Control Module |
| 13 | 30A Power Windows |
| 14 | 10A Inflatable Restraint Sensing and Diagnostic Module (SDM) |
| 15 | 2A A/T Shift Lock Control Assembly, Cruise Control On/Off Switch, Passenger Airbag Status Indicator |
| 16 | – |
| 17 | 10A Heating Ventilation Air Conditioning (HVAC) Control Module |
| 18 | – |
| 19 | 20A Heating Ventilation Air Conditioning (HVAC) Blower Switch |
| 20 | 10A Inflatable Restraint Sensing and Diagnostic Module (SDM) |
| 21 | 10A Audio System |
| 22 | 2A Ignition Switch |
| 23 | 10A Data Link Connector (DLC), Heating Ventilation Air Conditioning (HVAC) Control Module |
| 24 | 10A Instrument Panel Cluster, Theft Deterrent Control Module |
| Relay | |
| R1 | Blower Motor |
| Relay (Non-Serviceable) | |
| R2 | Power Door Lock (Lock) |
| R3 | Power Door Lock (Unlock) |
| R4 | Driver Door Lock Actuator (Unlock) |
| R5 | Interior Lamps |
Some relays can be attached to the back side of the block: Accessory (Power Window, Sunroof, Heated Seat, Windshield Wiper/Washer Switch) and Run (Heating Ventilation Air Conditioning).
Engine compartment
Under the hood, the main fuse and relay box is located on the front left, near the battery.
Check the purpose of the block elements with your diagrams (legend) on the back of the protective cover.
Diagram
Designation
| 1 | 10A Air Conditioning Compressor Clutch Relay |
| 2 | 15A Engine Control Module (ECM) |
| 3 | 10A 3.5L (LZ4, LZE): Engine Control Module (ECM) |
| 10A 2.4L (LAT): Generator Battery Disconnect Control Module, Starter Generator Control Module (SGCM) | |
| 4 | 10A 1-2 Shift Solenoid Valve, 2-3 Shift Solenoid Valve, 4-3 Shift Solenoid Valve, Torque Convertor Clutch Pulse Width Modulation (TCC PWM) Solenoid Valve, Transmission Control Module (TCM) |
| 5 | 10A 3.6L (LY7): Mass Air Flow (MAF)/Intake Air Temperature (IAT) Sensor |
| 20A 2.4L (LAT): Starter Generator Control Module (SGCM) Coolant Pump, Heater Coolant Pump | |
| 6 | 10A Evaporative Emission (EVAP) Canister Purge Solenoid Valve, Heated Oxygen (HO2S) Sensors, Mass Air Flow (MAF)/Intake Air Temperature (IAT) Sensor (2.4L (LAT, LE5, LE9)) |
| 7 | 10A Left Headlamp (Low Beam) |
| 8 | 15A Horn Relay |
| 9 | 10A Right Headlamp (Low Beam) |
| 10 | 15A Front Fog Lamp Relay |
| 11 | 10A Left Headlamp (High Beam) |
| 12 | 10A Right Headlamp (High Beam) |
| 13 | 10A 2.4L (LAT, LE5, LE9), 3.6L (LY7): Engine Control Module (ECM), Telematic Vehicle Localization and Immobilization Control Module |
| 14 | 25A Wiper 1 Relay, Wiper 2 Relay, Windshield Wiper Motor Assembly |
| 15 | 10A ABS (Electronic Brake Control Module (EBCM)) |
| 16 | 10A 2.4L (LAT, LE5, LE9), 3.6L (LY7): Engine Control Module (ECM), Telematic Vehicle Localization and Immobilization Control Module |
| 17 | 30A Cooling Fan Relay №1 |
| 18 | 30A Cooling Fan Relay №2 |
| 40A 3.6L (LY7 – 2012): Cooling Fan Relay №2 | |
| 19 | 30A Blower Motor Control Module, Blower Motor Relay, “RUN” Relay |
| 20 | 30A Body Control Module (BCM), Fuse (Passenger Compartment): “20”, “21”, “22”, “23”, “24” |
| 21 | 30A Fuse (Passenger Compartment): “12”, “14”, “15” |
| 22 | 60A Fuse (Luggage Compartment): “10”, “13”, “14”, “16”, “17”, “20”, “23” |
| 23 | 60A Fuse (Luggage Compartment): “1”, “2”, “5”, “6”, “22”, “25” |
| 24 | 60A ABS (Electronic Brake Control Module (EBCM)) |
| 25 | 50A Body Control Module, Fuse (Passenger Compartment): “1”, “2”, “5”, “6”, Accessory Relay |
| 26 | 30A Starter Relay |
| 41 | 80A 2.4L (LE5, LE9, LAT): Power Steering Control Module |
| 42 | 10A Transmission Control Module |
| 43 | 15A 3.6L (LY7): Fuel injectors (ODD), Ignition Coil/Modules (ODD) |
| 15A 2.4L (LE5 or LE9): Ignition Coils | |
| 15A 3.5L (LZ4, LZE): Ignition Control Module | |
| 44 | 15A 3.6L (LY7): Fuel Injectors (EVEN), Ignition Coil Modules (EVEN) |
| 10A 2.4L (LE5, LE9, LAT), 3.5L (LZ4, LZE): Fuel Injector | |
| 45 | 10A 3.5L (LZ4, LZE), 3.6L (LY7): Heated Oxygen Sensor (HO2S) Bank 1 Sensor 2, Heated Oxygen Sensor (HO2S) Bank 2 Sensor 2 |
| 46 | 15A Daytime Running Light Relay |
| 47 | 10A Stop Lamp Relay |
| 50 | 20A Power Window |
| 51 | 10A 2.4L (LAT): Starter Generator Control Module (SGCM) |
| 10A 3.5L (LZ4, LZE): Engine Control Module (ECM) | |
| 52 | 10A Secondary Air Injection (AIR) Pump Relay |
| 20A Transmission Auxiliary Fluid Pump Control Module | |
| 54 | 5A Body Control Module (Regulated Voltage Control) |
| 15A 2.4L (LAT): Body Control Module (Regulated Voltage Control) | |
| 55 | 30A DC/AC Inverter |
| 56 | 30A ABS (Electronic Brake Control Module (EBCM)) |
| 57 | – |
| Relay | |
| 28 | Cooling Fan (№1 (Left)) |
| 29 | Cooling Fan |
| 30 | Cooling Fan (№2 (Right)) |
| 31 | Starter Motor |
| 32 | Run/Crank (Ignition) |
| 33 | Engine Control Module (ECM) |
| 34 | Air Conditioning Compressor Clutch |
| 35 | Headlamp (High Beam) |
| 36 | Front Fog Lamp |
| 37 | Horn |
| 38 | Headlamp (Low Beam) |
| 39 | Wiper (№1) |
| 40 | Wiper (№2 – Windshield Wiper Motor) |
| 48 | Daytime Running Light |
| 49 | Stop Lamp |
| 53 | Secondary Air Injection (AIR) Pump |
| Transmission Auxiliary Fluid Pump Control Module | |
| Diode | |
| 27 | Wiper 1 Relay, Wiper 2 Relay |
Luggage compartment
In the luggage compartment, the fuse and relay box is located behind the trim on the left side.
Diagram
Allocation
| 1 | 30A Passenger Seat Controls |
| 2 | 30A Driver Seat Controls |
| 3 | – |
| 4 | – |
| 5 | 10A Evaporative Emission (EVAP) Canister Vent Solenoid Valve |
| 6 | 10A Park Lamps Relay (Body Control Module (BCM), License Lamps, Park/Turn Signal Lamps, Tail Lamps, Tail/Stop and Turn Signal Lamps), Instrument Panel Dimming |
| 7 | – |
| 8 | – |
| 9 | 25A Sunroof Control Module, Sunroof Shade Module |
| 10 | 15A Sunroof Control Module |
| 11 | – |
| 12 | – |
| 13 | 25A Audio Amplifier |
| 14 | 15A Heated Seat Controls |
| 15 | – |
| 16 | 7,5A Digital Radio Receiver, Garage Door Opener Transmitter, Remote Control Door Lock Receiver (RCDLR) |
| 17 | 10A Back-Up Lamps Relay |
| 18 | – |
| 19 | – |
| 20 | 20A Cigar Lighter, Auxiliary Power Outlet (Console or Front) |
| 21 | – |
| 22 | 10A Trunk Release Relay |
| 23 | 30A Rear Window Defogger |
| 24 | 10A Heated Mirrors |
| 25 | 15A Fuel Pump Relay |
| Relay | |
| 26 | Rear Window Defogger, Heated Mirrors |
| 27 | Park Lamps (Back-Up Lamps, Body Control Module (BCM), Garage Door Opener Transmitter, HVAC Control Module, License Lamps, Park/Turn Signal Lamps, Tail Lamps, Tail/Stop and Turn Signal Lamps) |
| 28 | – |
| 29 | – |
| 30 | – |
| 31 | – |
| 32 | – |
| 33 | Back-Up Lamps, Inside Rearview Mirror |
| 34 | – |
| 35 | – |
| 36 | Trunk Release |
| 37 | Fuel Pump |
| Diode | |
| 38 | Trunk Release |
Fuse number 20 for 20A is responsible for the operation of the cigarette lighter.
On our channel we have also prepared a video on this article, watch and subscribe.
If you have any questions, ask them in the comments.
My obd2 port is not communcaing with my car a 2010 cbevy malibu lt. Which fuse or relay would cause this. Also my abs and traction control are not working ,whick fuse andor relay should i check. Thank you.randy