The 1st generation Volvo S60 was produced in 2000, 2001, 2002, 2003, 2004, 2005, 2006, 2007, 2008, 2009 with body designation RS, RH. During this time, the model has been restyled. In our article you will find information about the location of electronic control units, a description of the fuses and relays for the Volvo S60 with fuse box diagrams, photo examples of their performance and locations. Select the fuse responsible for the cigarette lighter.
The purpose of the fuses and relays may differ from the one shown and depends on the year of manufacture, the region of delivery and the level of electrical equipment of your car.
Contents
Location
General layout of electronic control units
Assignment
| 1 | Air conditioning electronic control unit |
| 2 | A/C/heater blower control box – next to blower motor |
| 3 | Vehicle tilt sensor (anti-theft system) |
| 4 | Anti-theft horn – behind front right wheel arch trim |
| 5 | Volume change sensor (anti-theft system) – ceiling panel |
| 6 | Anti-theft signal sensor – in the multifunction control unit 3 |
| 7 | Electronic control unit for audio system |
| 8 | Auxiliary heater control unit, if installed |
| 9 | Battery – under hollow luggage compartments |
| 10 | Control unit for the cruise control system, built into the electronic engine control unit. |
| 11 | Diagnostic connector (DLC) |
| 12 | Differential lock control unit – on the rear differential (4×4) |
| 13 | Control unit for electrical equipment of the driver’s door – in the door – functions: Central locking, indicators of an open or not tightly closed door, electric drive / heater of rear-view mirrors on the doors, electric drive of windows, lighting lamps in door mirrors |
| 14 | Passenger’s door electrical control unit – in the door – functions: Central locking, door open or not tightly closed indicators, electric drive / heater of rear-view mirrors on the doors, power windows, lighting lamps in the door mirrors |
| 15 | Cooling fan motor control unit |
| 16 | Fuse/Relay Box, Engine Compartment 1 |
| 17 | Engine Compartment Fuse/Relay 2 – Under Engine Compartment Fuse/Relay 1 |
| 18 | Fuse/Relay Box, Dashboard 1 |
| 19 | Fuse/Relay Box, Instrument Panel 2 |
| 20 | Fuse/Relay Box, Luggage Compartment 1 |
| 21 | Fuse/relay box in luggage compartment 2- next to battery |
| 22 | Headlight control unit, left (models with xenon headlights) |
| 23 | Headlight control unit, right (models with xenon headlights) |
| 24 | Sound signals |
| 25 | Immobilizer – in the electronic engine control unit |
| 26 | Immobilizer ring antenna – near the ignition switch |
| 27 | Instrument Cluster Control Unit – Dashboard |
| 28 | Lighting control unit – behind the headlight switch |
| 29 | Multifunction control unit connected to instrument panel fuse/relay box 2 – functions: Anti-theft system, central locking, power windows, windshield wiper/washer, headlight wiper/washer, power steering, immobilizer, headlights, turn signals/alarm , horn, front / rear dimensions, starter, heated seats. Headlight range control, fuel pump, glove box light, central brake light. |
| 30 | Multifunctional control unit 2-connected to fuse/relay box, luggage compartment 1 – functions: Anti-theft system, central locking, taillights, fuel gauge, interior lamps, rear window defroster, accessory power connector – rear, for fuel heater filter — Diesel, rear seat head restraints. |
| 31 | Multifunctional control unit 3 – in the interior rearview mirror – functions: Central locking, anti-theft system, sunroof, rain sensor, interior lamps, seat belt reminder |
| 32 | Navigation system control unit |
| 33 | Ambient temperature sensor – in the mirror of the right door |
| 34 | Rain sensor (if installed) |
| 35 | The relay of system of blocking of doors from accidental opening, a lion. – at the door |
| 36 | The relay of system of blocking of doors from accidental opening, the rights. – at the door |
| 37 | Power Seat Control Module – Under Seat, Driver’s Side |
| 38 | Side impact sensor, left front – B-pillar |
| 39 | Side impact sensor, right front – B-pillar |
| 40 | Side impact sensor, rear left – behind the support on the rear seat cushion |
| 41 | Side impact sensor, rear right – behind the support on the rear seat cushion |
| 42 | SRS electronic control unit |
| 43 | Steering Wheel Position Sensor Box – Connected to Fuse/Relay Box 2 Under Dashboard |
| 44 | Steering Wheel Electrical Control Module – Behind the Steering Wheel – Functions: Audio System, Cruise Control (Cruise Control), Horn, Turn Signals, Windshield Wiper/Washer, Low/High Beam, Trip Computer |
| 45 | Sunroof electric control unit |
| 46 | Suspension control unit – side of center console |
| 47 | Electronic gearbox control unit |
| 48 | Gear shift control unit |
| 49 | Telematics block |
Passenger compartment
Fuse box 1
At the left end of the dashboard behind the protective cover is the first fuse box.
Check the purpose of the elements with your diagrams on the cover of the blocks.
Diagram
Designation
| 1 | 10A 2001-2002: Dipped beam, left |
| 15A 2003-2004: Low beam, Bi-Xenon | |
| 25A 2005-2009: Power driver’s seat | |
| 2 | 10A 2001-2002: Dipped beam, right |
| 20A 2003-2004: High Beam | |
| 25A 2005-2009: Power Passenger Seat | |
| 3 | 15A 2001-2002: Low beam |
| 30A 2003-2004: Power driver’s seat | |
| 30A 2005-2009: Air conditioning fan | |
| 4 | 20A 2001-2002: High Beam |
| 30A 2003-2004: Power Passenger Seat | |
| 25A 2005-2009: Control unit right, front door | |
| 5 | 30A 2001-2002: Power driver’s seat |
| 15A 2003-2004: Power steering, vacuum pump | |
| 25A 2005-2009: Left control unit, front door | |
| 6 | 30A 2001-2002: Power Passenger Seat |
| 5A 2004; Bi-Fuel: Gas cylinder valve | |
| 10A 2005-2009: General lighting, ceiling (RCM), upper electronic control unit (UEM) | |
| 7 | 15A 2001-2004: Heated seat (front left) |
| 15A 2005-2009: Sunroof | |
| 8 | 15A 2001-2004: Heated seat (front right) |
| 7.5A 2005-2009: Ignition Switch, SRS, Engine Control Module (ECM), Passenger Side SRS Disable (PACOS), Electronic Immobilizer (IMMO), Transmission Control Module (TCM; diesel and R-models – for 2006 of the year) | |
| 9 | 5A 2001-2004: ABS / STC (2003-2004) / DSTC (2003-2004) |
| 5A 2005-2009: OBDII, Light Switch (LSM), Steering Wheel Angle Sensor (SAS), Steering Wheel Control Module (SWM) | |
| 10 | 15A 2001-2002: High beam, left |
| 20A 2005-2009: Audio | |
| 11 | 15A 2001-2002: High Beam, Right |
| 30A 2005-2009: Audio Amplifier | |
| 12 | 15A 2001-2004: Headlight Corrector (2004), headlight cleaners |
| 10A 2005-2009: RTI display | |
| 13 | 20A 2001-2002: 12V socket |
| 15A 2003-2004: 12V socket | |
| 5A 2005-2009: Phone | |
| 2005-2009: 14-38 – Not used | |
| 14 | 5A Power Passenger Seat, Front Seat Belts (2001-2002) |
| 15 | 5A 2001-2003: Audio, VNS |
| 5A 2004: Audio RTI | |
| 16 | 20A Audio |
| 17 | 30A Amplifier |
| 18 | 5A 2001-2002: Front fog lights |
| 15A 2003-2004: Front fog lights | |
| 19 | 10A 2001-2003: VNS |
| 10A 2004: RTI display | |
| 20 | 5A 2002: Transport switch |
| 21 | 20A Automatic transmission, transmission selector lock, D2 |
| 22 | 20A Direction indicators |
| 23 | 5A Light switch, diagnostic socket, steering wheel module, climate control unit / comfort unit |
| 24 | 10A 2001-2002: Air conditioner control unit, power driver’s seat, instrument cluster |
| 10A 2003-2004: Air conditioner control unit, power driver’s seat, instrument cluster, parking heater | |
| 25 | 10A 2001-2002: Ignition Switch, Central Electronic Module, Starter Relay |
| 10A 2003: Ignition switch, SRS, starter relay, engine control unit | |
| 10A 2004: Ignition switch, central electronic module, starter relay, engine control unit | |
| 26 | 30A Climate control unit |
| 27 | 15A 2001-2002: Front door electronic module |
| 15A 2004: FOUR-C active chassis | |
| 28 | 10A Ceiling module, interior lighting |
| 29 | 10A Phone |
| 30 | 10A 2001-2002: Parking lights (left) |
| 7.5A 2003-2004: Parking lights (left) | |
| 31 | 10A 2001-2002: Parking lights (right), license plate light |
| 7.5A 2003-2004: Parking lights (right), license plate light | |
| 32 | 10A Central Electronic Module, Visor Mirror Light, Power Steering, Glove Box Light (2003-2004), Interior Light (2003) |
| 33 | 15A Fuel pump |
| 34 | 15A Hatch |
| 35 | 25A Central locking, power windows, left power mirror |
| 36 | 25A Central locking, power windows, right power mirror |
| 37 | 30A Rear power windows, child lock (2003-2004) |
| 38 | 5A 2003-2004: Anti-theft siren |
Fuse box 2
Another fuse box is installed under the instrument panel, next to the diagnostic connector, mainly in 2004-2009 models.
Photo – example
To access it, you need to unscrew the protection mount.
Diagram
Allocation
| 1 | 15A Seat heating, right side |
| 2 | 15A Seat heating, left side |
| 3 | 15A Horn |
| 4 | Reserve socket |
| 5 | 10A Infotainment system |
| 6 | Reserve socket |
| 7 | Reserve socket |
| 8 | 5A Burglar Siren |
| 9 | 5A Brake signal contacts, power |
| 10 | 10A Combined instrument panel (DIM), air conditioner (CCM), parking heater, power driver’s seat |
| 11 | 15A 12V socket (cigarette lighter), front seat, rear seat and refrigerator |
| 12 | Reserve socket |
| 13 | Reserve socket |
| 14 | 15A S60 R, 2005-2006: Headlight cleaners |
| 15 | 5A ABS, STC/DSTC |
| 16 | 10A Electronic Servo Control (ECPS), Active Bi-Xenon (HCM), headlight beam height adjustment |
| 17 | 7.5A Fog lamp, front left |
| 18 | 7.5A Fog lamp, front right |
| 19 | Reserve socket |
| 20 | 5A Coolant pump (V8) |
| 21 | 10A Communication control unit (TOM), reverse gear lock (M66) |
| 22 | 10A Main beam, left |
| 23 | 10A Main beam, right |
| 24 | Reserve socket |
| 25 | Reserve socket |
| 26 | Reserve socket |
| 27 | Reserve socket |
| 28 | 5A Power passenger seat |
| 29 | 7.5A Fuel pump |
| 30 | 5ABUS |
| 31 | Reserve socket |
| 32 | Reserve socket |
| 33 | 20A Vacuum pump |
| 34 | 15A Headlight washer fluid pump |
| 35 | Reserve socket |
| 36 | Reserve socket |
The number 11 fuse is responsible for the cigarette lighter.
Relay box
This relay box is installed under the panel in the early Volvo S60 models. Also known as the CEM Central Electronic Module. Looks like this:
Diagram
Appointment
| 1 | — |
| 2 | Auxiliary ignition circuits |
| 3 | Main ignition circuits |
| 4 | — |
| 5 | — |
| 6 | power window – close, left rear door |
| 7 | power window – opening, left rear door |
| 8 | switching off the electric motors of the rear power windows, blocking the doors from accidental opening – rear doors |
| 9 | high beam headlights |
| 10 | Marker lamps |
| 11 | Daytime lighting system |
| 12 | low beam headlights |
| 13 | Power Window Relay – Close, Right Rear Door |
| 14 | Power Window Relay – Open, RH Rear Door |
| 15 | Ignition Auxiliary Relay 2 |
| 16 | transmission control system |
| 17 | — |
| 18 | — |
| 19 | — |
| 20 | — |
| 21 | Telematics |
| 22 | — |
| 23 | — |
| 24 | — |
| 25 | — |
| 26 | — |
| 27 | Fog lights |
| 28 | Fuel pump relay |
| 29 | — |
| 30 | Fuel Leakage Relay |
| 31 | Jumper – left direction indicators |
| 32 | Jumper – right direction indicators |
| 33 | — |
| 34 | Jumper – dipped beam |
| 35 | — |
Engine compartment
On the left side of the engine compartment, next to the rack is a box with fuses and relays. There are several versions of this block with fuses and relays.
Type 1
Photo
Diagram and location
Decoding
- 60A – Glow plug control unit, Glow plugs, Glow plug
- 60A – Electric motor, electric cooling fan
- –
- –
- –
Fuse Diagram
Assignment
| 1 | 30A ABS |
| 2 | 30A ABS |
| 3 | 35A High pressure headlight washers |
| 4 | 25A Parking heater (option) |
| 5 | 20A Additional lights (option) |
| 6 | 35A Starter relay |
| 7 | 25A Windscreen wipers |
| 8 | 15A Fuel pump fuse |
| 9 | 15A Transmission control module (TCM), (V8, diesel, 6-cyl. petrol) |
| 10 | 20A Ignition coils (gasoline), engine control module (ECM), injection valves, (diesel) |
| 11 | 10A Fuel Pedal Position Sensor (AWP), AC Compressor, Fan, ECU |
| 12 | 5/15A Engine control module (ECM) (petrol), injectors, (petrol), air mass meter (petrol); air mass meter (diesel) |
| 13 | 10/15A Throttle control module (V8), V1S (6-cyl. petrol); throttle control module, solenoid valve, SWIRL (air mixture valve), fuel pressure regulator (diesel) |
| 14 | 10/20A Lambda probe (gasoline); lambda probe (diesel) |
| 15 | 10/15A Crankcase ventilation heater, solenoid valves, leak diagnosis (5-cyl. petrol); Crankcase ventilation heater (V8, 6-cyl. petrol), AC clutch (V8, 6-cyl. petrol), Solenoid valves, Leak diagnosis (V8, 6-cyl. petrol), ECM, (V8, 6-cyl. petrol ), air mass meter (V8), glow plugs (diesel) |
| 16 | 20A Dipped beam, left |
| 17 | 20A Dipped beam, right |
| 18 | Reserve socket |
| 19 | 5A Engine control module (ECM), power supply, engine relay |
| 20 | 15A Side lights |
| 21 | 20A 2009: Vacuum pump |
Relay diagram
Designation
- FMA1 – Starter
- FMA2 – Automatic glow plug relay, not I5D
- FMA3 – Main relay of the engine management system
- FMI2 – Relay, air conditioning
- FST1 – Windshield wiper relay, low/high speed
- FST2 – Interval wiper relay
- FST3 – Relay, high pressure headlight washer motor
Type 2
Photo – example
Circuit breakers
Scheme
Allocation
| F1 | 25A Additional heater control unit |
| F2 | 20A Accessories / Additional lights |
| F3 | 10A 2005: Throttle body (5-cyl. without turbocharger/bi-fuel) |
| F4 | 20A Gasoline: Lambda sensor 2004-2005; Diesel: Engine control module (ECM), high pressure fuel valve |
| F5 | 10/ 15A Engine management system (Air mass meter, engine control unit, injectors, crankcase ventilation heater, solenoid valves) |
| F6 | |
| F7 | 10A 2001-2004: Throttle control unit |
| F8 | 10A Fuel Pedal Position (AWP) Sensor, AC Compressor, ECU Fan (2003-2005) |
| F9 | 15A Horn 10A 2005; Bi-fuel LPG: LPG cylinder valve |
| F10 | – |
| F11 | 20A 2001-2004: A/C compressor, ignition coils, fan (2001-2002), solenoid valves (2004; diesel) |
| 2005: Ignition coils, relay coils | |
| F12 | 5A Brake lights |
| F13 | 25A Windshield wiper |
| F14 | 30A Anti-lock braking system ABS/ESP (DST C) |
| F15 | 15A 2004; Bi-Fuel: LPG bottle valve / 35A 2005: High pressure headlight washers |
| F16 | 15A Windshield wipers, headlight cleaners |
| F17 | 10/20A Right headlight – low beam (xenon) |
| F18 | 10 / 20A Left headlight – low beam (xenon), 15A 2005 Parking lights ahead |
| F19 | 30A Anti-Lock Braking System ABS/ESP (DSTC) |
| F20 | 15/20A Left headlight – high beam |
| F21 | 15/20A Right headlight – high beam, 2005 2005: Fuel pump |
| F22 | 25/35A Starter |
| F23 | 5A Engine control relay, engine control module (ECM) |
| F24 | — |
Relay diagram
Relay appointment
- Engine management system
- Glow plugs
- Starter
- Intermittent windshield wiper
- Headlight cleaner/washer
- AC compressor electromagnetic clutch
- Horn (signal)
- Windshield washer pump
- Windshield wiper motor
- Rear window washer pump motor
Additional security elements are installed on the reverse side of the block.
Diagram
Decoding
| F1 | 60A Glow Plugs |
| F2 | 60A Interior end block circuits: fuses (F5-7), (F25-27), (F32-33) |
| F3 | 60A Interior end block circuits: fuses (F3-4), (F8-11), (F16-19), (F34-38) |
| F4 | 60A Interior end block circuits: fuses (F1), (F12-15), (F20-24) |
| F5 | empty |
| F6 | empty |
| F7 | empty |
| F8 | 60A Cooling fan motor |
Luggage compartment
In the luggage compartment, on the left behind the interior protection, another block with fuses and relays is installed. Rotate the holder to access.
Type 1
The fuse box itself will look something like this.
Diagram
Assignment
| F1 | 10A Multifunction control unit 2, interior lighting – luggage compartment lighting |
| F2 | 10A Rear fog lights |
| F3 | 15A Stop lights |
| F4 | 10A Reversing lights |
| F5 | 5A Rear defroster, trailer electrical connector power relay |
| F6 | 10A Rear door opener |
| F7 | 10A Folding headrests |
| F8 | 15A Central locking – locking rear side doors / rear door hatch / fuel filler cap |
| F9 | 20A Trailer electrical connector |
| F10 | 5A Antenna booster, LED |
| F11 | 15A Accessories |
| F12 | – |
| F13 | – |
| F14 | 7.5A Stop lights |
| F15 | 20A Trailer electrical connector |
| F16 | 15A Socket in luggage compartment |
| F17 | 7.5A Fuel filter heater (Diesel), differential lock control unit |
| F18 | 15A Fuel filter heater (diesel) |
| 1 | — |
| 2 | — |
| 3 | — |
| 4 | Intermittent rear wiper relay |
| 5 | Bi-fuel Relay |
| 6 | A/C ECM Relay – Rear A/C |
| 7 | Rear Door Actuator Relay |
| 8 | Not used (2002) |
| 9 | Fuel Filler Lock Actuator Relay – Open |
| 10 | — |
| 11 | Central locking relay, right rear door – unlock |
| 12 | — |
| 13 | — |
| 14 | Rear wiper motor relay |
| 15 | — |
| 16 | — |
| 17 | — |
| 18 | — |
| 19 | Jumper – brake lights |
| 20 | Jumper – rear dimensions |
| 21 | Jumper – rear dimensions |
| 22 | Jumper-power connector for additional equipment in the luggage compartment |
| 23 | Jumper – fog lights |
| 24 | — |
| 25 | Rear Fog Lamp Relay – Trailer |
| 26 | Rear fog light relay |
| 27 | Brake light relay |
| 28 | Reverse lamp relay |
| 29 | Central locking relay, rear – double lock |
| 30 | Central locking relay, left rear door – unlocking |
| 31 | Fuel Filler Lock Actuator Relay – Close, Central Locking Relay – Rear Doors – Close (2002) |
| 32 | Fuel Filter Heater Relay (Diesel) |
| 33 | — |
| 34 | Rear defroster relay |
| 35 | Audio system |
| 36 | Trailer electrical connector power relay |
Type 2
Photo – example
Diagram
Designation
| 1 | 10A Reversing lamp |
| 2 | 20A Parking lights, fog lights, luggage compartment lights, license plate lights, brake lights |
| 3 | 15A Accessories (AEM) |
| 4 | Reserve socket |
| 5 | 10A Electronic equipment REM |
| 6 | 7.5A Rear seat entertainment system RSE (accessory) |
| 7 | 15A Wiring (30 power) |
| 8 | 15A Electrical socket in luggage compartment |
| 9 | 20A Rear door, right: power window, power window lock |
| 10 | 20A Rear door, left: power window, power window lock |
| 11 | Reserve socket |
| 12 | Reserve socket |
| 13 | 15A Diesel filter heater |
| 14 | 15A Subwoofer, rear air conditioning (A/C) |
| 15 | Reserve socket |
| 16 | Reserve socket |
| 17 | 5A Additional audio equipment |
| 18 | Reserve socket |
| 19 | 15A Folding headrest |
| 20 | 20A Wiring (15 power) |
| 21 | Reserve socket |
| 22 | Reserve socket |
| 23 | 7.5A AWD |
| 24 | Reserve socket |
| 25 | Reserve socket |
| 26 | 5A Parking assistance |
| 27 | 30A Main fuse: wiring harness to trailer, park assist, AWD |
| 28 | 15A Central locking (PCL) |
| 29 | 25A Trailer lighting, left: side lights, direction indicators |
| 30 | 25A Trailer lighting, right: brake light, rear fog lights, direction indicators |
| 31 | 40A Main fuse |
| 32 | Reserve socket |
| 33 | Reserve socket |
| 34 | Reserve socket |
| 35 | Reserve socket |
| 36 | Reserve socket |
| 37 | 20A Electric heated rear window |
| 38 | 20A Electric heated rear window |
That’s all. And if you know how to make the material better – write in the comments.