The first generation Ford Tourneo Connect was produced in 2002, 2003, 2004, 2005, 2006, 2007, 2008, 2009, 2010, 2011 and 2012. After that, from 2013 to the present, the 2nd generation of the model is being assembled. In our publication you will find a designation of the first generation Ford Torneo fuse boxes and relays, the location of the boxes, their diagrams and photographs. Note the cigarette lighter fuse.
This 1st generation ford torneo connect model has 2 main boxes with fuses and relays. One under the hood, behind the air filter, the second in the cabin. The purpose of their elements may differ from that shown and depends on the year of manufacture and the country of delivery.
Passenger compartment
It is located under the dashboard on the driver’s side, behind the protective cover.
Type 1
Photo for example
Diagram
Assignment
1 | Starter relay |
2 | Rear wiper relay |
3 | Interior lamp relay |
4 | Windshield wiper motor relay |
5 | – |
6 | – |
7 | Battery current monitoring relay |
8 | Relay 1 of the main ignition circuits |
9 | Heated rear window relay |
F30 | (10A) Headlamp switch |
F31 | (15A) Audio system |
F32 | – |
F33 | (7.5A) Battery current monitor relay, interior lamp relay |
F34 | (7.5A) Main ignition circuit relay 1, auxiliary heater control unit |
F35 | – |
F36 | (7.5A) SRS electronic control unit |
F37 | (7.5A) Headlamp switch, turn signal switch |
F38 | (7.5A) SRS electronic control unit |
F39 | – |
F40 | (7.5A) Instrument cluster, audio system |
F41 | – |
F42 | (15A) Brake light switch |
F43 | (20A) Rear wiper relay, windshield wiper motor |
F44 | (15A) Cigar lighter |
F45 | – |
F46 | (15A) Trailer socket |
F47 | (5A) Rearview mirror select switch |
F48 | (7.5A) Instrument panel, anti-theft system, anti-theft control module, parking control module, alarm relay / turn signal relay |
F49 | (25A) Heated rear window |
F50 | (7.5A) Power door mirror (passenger side), power door mirror (driver side) |
F51 | – |
F52 | – |
F53 | (10A) Reversing light (s), windshield washer nozzle heaters |
F54 | – |
F55 | – |
F56 | (20A) Windshield wiper motor relay, rear wiper relay, windshield wiper motor, windshield wiper mode switch |
F57 | (7.5A) Headlight (right), fuel pump select switch, trailer electrical connector, rear combination lamp (right) |
F58 | (7.5A) Headlamp (left) / rear combination lamp (left) |
F59 | (7.5A) Auxiliary heater control unit |
F60 | – |
F61 | (15A) Central locking / anti-theft control module, alarm relay / turn signal relay |
F62 | (7.5A) Left license plate light, right license plate light |
F63 | (20A) Anti-theft / central locking control module |
The fuse number 44, 15A, is responsible for the lighter.
Type 2
Diagram
Designation
117 | Not used |
118 | Not used |
119 | Not used |
120 | Headlamps, Low beam interrupt relay |
121 | Front fog lamp interrupt relay |
122 | Rear window defroster relay |
123 | Heater blower relay |
124 | Interior lamps relay |
125 | Windshield wipers relay |
126 | Rear unlock relay |
127 | Ignition overload relay |
128 | Battery saver relay (modified vehicle) |
130 | 15A Hazard flashers |
131 | 5A Power mirrors |
132 | 10A Light switch, Exterior lighting |
133 | Not used |
134 | Not used |
135 | Not used |
136 | 15A Horn |
137 | 7,5A Tire pressure monitoring system, Radio, Instrument cluster |
138 | 10A Reverse lamp |
139 | 20A Ignition supply (modified vehicle) |
140 | Not used |
141 | 7,5A Front/rear fog lamps |
142 | 15A Brake lamps |
143 | 20A Cigar lighter, Front power point |
144 | 10A Ignition supply (modified vehicle} |
145 | Not used |
146 | 20A Windshield wipers, Wiper switch |
147 | 15A Front fog lamps |
148 | 7,5A Recirculation, Instrument cluster |
149 | 10A Ignition supply /Battery supply (modified vehicle) |
150 | Not used |
151 | 15A Radio, Bluetooth/ Voice command module |
152 | 7,5A A/C switch, Park aid module |
153 | 7,5A Interior lamps, Battery saver |
154 | 15A Roof lamp (modified vehicle) |
155 | 10A Battery saver (modified vehicle) |
156 | 7,5A Right parking lamp/tail lamps |
157 | 7,5A License plate lamps |
158 | 10A Light swatch |
159 | 20A Rear heater blower fan (modified vehicle) |
160 | Not used |
161 | 7,5A Anti-lock brake system/ Roll stability control, Steering angle sensor |
162 | 7,5A Airbag module, Passenger airbag off indicator |
163 | 20A Locks |
164 | 20A Tire pressure monitoring system module |
165 | Not used |
166 | 25A Front power windows |
167 | 7,5A Rear window defroster/ heated mirror swatch |
168 | Not used |
169 | 20A Second power point |
170 | Not used |
171 | Not used |
172 | 10A Right rear turn signal (modified vehicle) |
173 | 10A Left rear turn signal (modified vehicle) |
174 | 20A Rear power point, Rear center console power point (modified vehicle) |
175 | 7,5A Left park lamps/ tail lamps |
176 | Not used |
177 | Not used |
178 | 25A Rear window defroster |
179 | 7,5A Instrument cluster, Passive anti-theft system, Accelerator pedal sensor, Tire pressure monitoring system, Rearview camera |
180 | 20A Front and rear window washer |
181 | Not used |
182 | Not used |
Engine compartment
To access, you need to release the latch and clamp of the side part and remove the unit cover.
Type 1
Check the assignment with your diagrams on the back of the block cover.
Diagram
Appointment
1 | Cooling fan motor relay 1 |
2 | Fully open throttle position relay |
3 | Daytime lighting relay |
4 | Glow plug relay |
5 | Headlamp high beam relay |
6 | Headlamp low beam relay |
7 | Windshield heater relay |
8 | Relay 1 of the main ignition circuits |
9 | Cooling fan motor relay 2 |
10 | Coolant heater relay 1 |
11 | Horn relay |
12 | Coolant heater relay 2 |
13 | Fuel pump relay |
14 | Engine control relay |
15 | – |
16 | Relay 2 main ignition circuits |
F1 | (40A) Instrument panel fuse / relay box |
F2 | (30A) Cooling fan motor resistor |
F3 | (30A) Instrument panel fuse / relay box |
F4 | (60A) Heated windscreen relay |
F5 | (50 / 40A) Cooling fan motor relay |
F6 | (60A) Glow plug relay |
F7 | (40A) Instrument panel fuse / relay box |
F8 | (20A) Starter relay |
F9 | (20A) Engine management relay |
F10 | (10A) Alternator, diagnostic connector (DLC) |
F11 | (20A) Auxiliary heater |
F12 | (15A) Fuel pump relay |
F13 | (30A) ABS control module |
F14 | – |
F15 | (10A) Headlamp high beam relay |
F16 | (10A) Headlamp low beam relay |
F17 | (10A) Headlamp low beam relay |
F18 | (40A) Glow plug relay (Diesel) |
F19 | (10A) Headlamp switch |
F20 | (10A) Instrument panel, instrument cluster control module |
F21 | (15A) Horn relay |
F22 | (20A) Daytime running light relay, low beam relay |
F23 | (20A) SRS control module |
F24 | – |
F25 | (10A) Headlamp high beam relay, instrument cluster |
F26 | (10A) Fully open throttle position relay |
F27 | (10A) Fuel filter water presence sensor |
F28 | (20A) Headlamp switch |
F29 | (15A) Heated seats |
F64 | (30A) Air conditioner / heater blower motor |
F65 | – |
Type 2
Diagram
Appointment
1 | 7,5A Heated windshield telltale |
2 | 40A Right heated windshield, Modified vehicle – Rear heater blower fan, Ignition supply |
3 | 50A Left heated windshield, Modified vehicle – Batteiy supply |
4 | 20A Fuel pump |
5 | 10A Powertrain control module keep alive power, Canister solenoid |
6 | 15A Powertrain control module, Data link connector |
7 | 20A Ignition switch |
8 | 15A Headlamps |
9 | 40A Passenger compartment fuse panel II |
10 | 25A Modified vehicle – Rear turn signal, Battery supply |
11 | 40A Ignition overload, Passenger compartment fuse panel |
12 | 30A Anti-lock brake system / Roll stability control pump motor |
13 | 30A Heater blower motor |
14 | 10A Powertrain control module relay |
15 | 20A Anti-lock brake system / Roll stability control valves |
16 | 30A Cooling fan – low |
17 | 50A Cooling fan – high |
18 | 25A Daytime running lamps, Low beam interrupt relay |
19 | 50A Passenger compartment fuse panel III |
20 | A/C clutch relay |
21A | Right heated windshield relay, Modified vehicle – Rear fan relay |
21B | Starter lock relay |
21C | High beam headlamp relay |
21D | Powertrain control module relay |
22 | 10A Powertrain control module, Auxiliary connector, Fuel injectors |
23 | 10A Right low beam headlamp |
24 | 10A A/C clutch solenoid |
25 | 10A Left low beam headlamp |
26 | 10A Mass air flow sensor, Brake switch, Backup lamps relay, Exhaust gas recovery valve stepper motor, Electronic vapor canister purge valve, Heated oxygen sensors, Floor shifter, Transmission range sensor |
27 | Not used |
28 | 15A Powertrain control module vehicle power 1 |
29 | 15A Auxiliary connector, Coil on plugs |
30A, 30B | 70A Cooling fan high relay |
30C | Cooling fan low relay |
30D | Left heated windshield relay |
31A | Backup lamp relay |
31B | Fuel pump relay |
31C | Daytime running lamps relay |
31D | Low beam headlamps relay |
31E | Modified vehicle – Right rear turn signal relay |
31F | Front fog lamps |
32 | Cooling fan diode |
33 | Fuel pump relay diode |
34 | Gear shifter diode |
35 | 30A Start lock relay |
36 | Modified vehicle – Left rear turn signal relay |
Want to help complete the material? Write in the comments.
Which relay plug in black box is responsible for indicators on 2003 ford connect, inside glove box fuses or anywhere else?
where can i find the cigarette lighter fuse nothing in main fuse box and nothing in glove fuse box please advise 2007 model
where is the heater relay on a 2004 ford transit connect turneo under the bonnet or where?